EXCURSION WIRING FOR MODIFICATIONS f650 DASH AND GAUGES.sdr

R 31 PIN MOLEX XRC BULKHEAD CONNECTOR R R R R SHEET ONE YEL -BLK YELLOW SIX PIN MOLEX 150 CONNECTOR 2 BLK BLACK AIR PRESSURE GAUGE HARNESS ORANGE OBD CABLE PURPLE PURPLE YEL AIR LOCKER 1 11 GREEN 12V 3 AMP FUSED FROM PANEL GS MAIN AIR PRESSURE SENSOR GS MAIN AIR PRESSURE SENSOR RETURN BLACK 15 16 GS AIR BAG PRESSURE SENSOR RETURN 18 12V 2AMP 25 GROUND TO DASH FOG LIGHTS 5V REGULATED 24 27 ACR CONTROL SIGNAL 23 RED ACR SWITCH POWER 22 26 ACR LED 21 RED-BLACK BOSCH 5 PIN RELAY UNDER DASH RED GREEN GREEN TRANSMISSION TEMPERATURE 20 GRAY/ORANGE 8 3 2 7 1 BLACK MICRO SWITCH UNDER DASH FOGS WITH HIGHS DISABLE RED SOLDER SPLICE IN OEM HARNESS HIGH BEAM GRAY/ORANGE SOLDER SPLICE IN OEM HARNESS YELLOW 7 5 THIS PAGE MULTIFUNCTION SWITCH HEADLIGHT SWITCH C1 TRANSMISSION TEMPERATURE GREEN RED WHITE BLACK 2 BLUE BLACK 1 GREEN RED BLK ARB CKSA12 HARNESS DIFFERENTIAL TEMPERATURE CONNECT TO F2 48 15 AMP OR F2 43 15 AMP IN CJB (FUSE BOX) MAIN FUSE BOX HOT ON RUN OR ACC ADD -A-FUSE 2 AMPS AEROFORCE 5V REGULATOR ACR REMOTE SWITCH HOT ON RUN OR ACC YELLOW RED 12V FUSED 2 AMP WHITE DIFFERENTIAL TEMPERATURE CUSTOM HARNESS A1 BLACK 19 WHITE GS AIR BAG PRESSURE SENSOR 17 BLUE RED WINCH POWER 13 14 ORANGE PRESSURE SWITCH 12 RED DRK GRN AIR LOCKER 2 10 BLK PSI PSI C1 GLOWSHIFT GS-C713_DUAL AIR PRESS GAUGE NOTES 174 TRANS TEMP ALL WIRES ARE 18 GAUGE UNLESS OTHERWISE NOTED ON DIAGRAM R MEANS CIRCUIT IS RELAYED COPYRIGHT 2011 BION ROGERS * * * OBD II CONNECTOR 12V HEADLAMP SWITCHED SOURCE 18 GA PRESSURE GAUGE LIGHT DIMMING 18 GA GROUND TO DASH TO DASH ILLUMINATION 2 PIN PIN MOLEX 150 CONNECTOR 1 DIODE 1 AND 2 ARE INSTALLED TO ALLOW EITHER COMPRESSOR SWITCH TO EFFECT LOCKER OPERATION. DIODE 1N5402 DIODE 1N5402 BLACK RED-YEL BLU-WHT FOUR PIN MOLEX 150 CONNECTOR 1 * 13.58 VOLTS ON PILLAR POD AIR PRESSURE 15 151 GLOWSHIFT BLACK BLACK PURPLE RED DASH ILLUMINATION AIR LOCKER SWITCH 2 PURPLE YEL -BLK BUMPER OFFROAD LIGHTS BLK BLU-WHT BLK PURPLE DRK GRN YEL GREEN RED YEL BLK AIR LOCKER SWITCH 1 YELLOW CUSTOM HARNESS A1 VLD1A60B SWITCH 3 RED BUMPER DRIVING LIGHTS BLK BLU-WHT RED BLK PURPLE RED BLK PURPLE GROUND GROUND 1 2 REAR AIRBAGS 3 7 8 2 ARB CKSA12 MINI COMPRESSOR DIODE 1N5402 RED 12V 5 AMP FROM PANEL RED BLK WINCH POWER PURPLE BLK RED ORANGE bosch DIODE 1N5402 ORANGE LIGHT BLUE 8 5 3 ARB CKMTA12 MAIN COMPRESSOR 9 GREEN ORANGE BLUE 2 2 REAR BUMPER FLOOD LIGHTS BLK BLU-WHT RED-YEL PURPLE BLK PURPLE RED BLK RED BUMPER 4X4 LIGHTS 7 INTERNAL CIRCUIT DIAGRAM 81 3 4 6 CONTURA V SERIES VLD1A60B-AUCAT-100 DPDT MOMENTARY F650 DASH AND GAUGE WIRING DIAGRAM RED BLUE PINK 7 BUMPER DRIVE LIGHTS MAIN COMPRESSOR 5 6 PINK REAR BUMPER FLOOD 4 LIGHT BLUE AIR BAG DOWN AIR BAG UP ROCK/ROOF LIGHTS 2 3 1 CARLING CONTURA VID1J66B SERIES SWITCHES 2005 EXCURSION 2011-12 MODIFICATIONS PROJECT